Kad 32 diesel

[nugent]

Been asked to service a twin set up of kad 32 engines

To me an engine is an engine what ever its bolted to , but having never worked on one before I need to go,with the correct parts ,

Oil ,air (is there one) fuel filters impellor and raw water strainer , change drive belts, change gearvoil, is there any other item I have missed? apart from obvious engine oil check adjust various inspect as you would any other beast been stood up 2 years with Volvo legs,

Also am I right in saying there is no pumps in the legs?

Cheers in advance for advice given,,,,

[nugent]

Did find this surfing



I came across this list of compatible parts for the KAD32

Volvo KAD32

Power steering Belt - Volvo No. 973487
Car shop - 6375MC or MBF1013

Alternator Belt - Volvo No. 977542
Car shop - 6469MC or MMB987

Primary Belt - Volvo No. 861564
Car shop - 7PK925 78359 or MMR7925

Compressor Belt - Volvo No.3581460
Car shop - 68376 6PK1138 or MMR61150

Air Filter - Volvo No.463505
Car shop - Champion U531 (As used in 240 1.7DL.GL B17A 1979 onwards)

FRAM Filters
air CA4365,
oil PH 2861B ,
diesel P5770

[beamishken]

probably going to need bellows & anodes for legs & anodes for heatexchangers, antifreeze mixture to re-winterise it if your going to test run the engines on a hosepipe
greasegun for greasing u/j s while the legs are off & maybe racor filters for prefilters

[nugent]

Anodes have been ordered was going to check bellows first on my arrival, there's a local dealer with them in stock, been sat in water at Windsor last 2 year but engines have not been run up what so ever,

Thanks for input appreciated Nuge,,,,,

[beamishken]

think you should run them up before you spend money unless you know they were winterised as if they werent they could be f----d it was a v harsh winter one before last

[peterwhite]

Also check the supercharger oil and when it was last changed. Doesn't take much but it's hugely expensive stuff. Right about the belts. Kads go through belts like mad. Need a full set every year and expect a lot of belt dust around the front of them. This is normal.

[nugent]

this is a sunseeker boat been moored 2 years in Windsor , for his sons temporary accomadation apparently it was cheaper than renting,,,,,,,,,,

some people have to much cash me finks, be on the business books some place for sure

[nugent]

Woman I love em,,,

Just spoke with the man of the house, wife gave me details of his other boat lol
Twin engines TAMD74P EDC with MG5075A-E.
Now I have to start all over again

[nugent]

Any one recomend best supplier for service parts ?

[mitchc]

Keyparts, see the link in your other thread....

Sent from my iPhone using Rib.net

[nugent]

Cheers appreciated

[falcon0310]

i thort be small boat with 32s, hope you have oil drum... 74p s must take 25 lts each

[peterwhite]

DB Marine in maidenhead. Will send out parts immediately and extremely helpful. 01628 526032 ask for Richard or Mark. Used them for the last 10 years absolutely superb.